Sailing Uma · video

What this video covers

Dan and Kika replace Uma's cockpit drains and build a battery box in the cockpit locker as part of a larger electrical system overhaul. The old cockpit drains — 1.5-inch tubes routed through seacocks — are ground out and replaced with fiberglass stern-tube stock, chosen because it is stronger than hand-laminated tube without vacuum bagging or autoclaving.▶ 8:37 The new tubes are roughly double the diameter, giving approximately four times the flow area and eliminating the through-hull restriction; Dan estimates the cockpit will drain four to five times faster.▶ 3:44 The drain replacement was motivated by a rat that chewed through the original through-hull fitting while the boat was in Florida, nearly sinking Uma.▶ 1:52 With the drains glassed in and cured, Dan builds a plywood battery box — primed, painted, and assembled outside the locker before installation — to hold five of the planned ten lithium batteries elevated above the hull and above the waterline.▶ 13:16 The second bank of five goes under the companionway steps, separated by a watertight bulkhead, giving two independent Ocean Volts battery banks each with its own BMS.▶ 1:06 Kika spends four hours writing patron names inside the locker before sealing them under a final paint coat.▶ 19:49 Cockpit lid reinforcement and waterproofing, started in Guatemala in 2017, is deferred to the next episode.▶ 29:24

More from Sailing Uma

Uma is Ready to Launch! (But there's a catch) | Step 489Jun 2026How Many Sails Does it Take To Replace a Diesel Engine? | Step 488May 2026Turning Our Powerboat Back Into a Sailboat | Step 487May 2026We Cut our Mast in Half | Step 486May 2026

From Sailing Uma — see the channel’s boat, crew, and every analysed video.